the12volt.com spacer
the12volt.com spacer
the12volt.com spacer
the12volt.com spacer
icon

Compustar CM6200 Wont Go Into Reservation Mode


Post ReplyPost New Topic
< Prev Topic Next Topic >
icarus_icarus 
Copper - Posts: 229
Copper spacespace
Joined: November 01, 2005
Location: Ontario, Canada
Posted: August 08, 2017 at 12:23 AM / IP Logged Link to Post Post Reply Quote icarus_icarus
My CM6200 on my 04 Jeep TJ manual has been working perfectly fine until about two months ago now.
Now when I try to put it in reservation mode, when I open and close the door part, it immediately shuts off when the door is closed and doesn't go into reservation mode (or lock the doors which it used to do.) Once in a while it works fine, most of the time it doesn't now...
Any ideas?
Thanks :)
·Ď˘ĺrµ§·
Compustar CM6200 Wont Go Into Reservation Mode -- posted image.
icarus_icarus 
Copper - Posts: 229
Copper spacespace
Joined: November 01, 2005
Location: Ontario, Canada
Posted: November 10, 2018 at 10:56 PM / IP Logged Link to Post Post Reply Quote icarus_icarus
Still doing this on and off randomly. I've gone through the wiring and it all looks good. Not sure what it could be...
·Ď˘ĺrµ§·
Compustar CM6200 Wont Go Into Reservation Mode -- posted image.
lurch228 
Silver - Posts: 1,338
Silver spacespace
Joined: August 08, 2012
Posted: November 11, 2018 at 4:51 AM / IP Logged Link to Post Post Reply Quote lurch228
Try checking the factory door switch clean or replace if working intermittently. If the door switch is not making a good connection and the R/S see more than a single connection instance it will think the door was open closed and reopened and cancel the reservation mode.
icarus_icarus 
Copper - Posts: 229
Copper spacespace
Joined: November 01, 2005
Location: Ontario, Canada
Posted: November 11, 2018 at 4:53 AM / IP Logged Link to Post Post Reply Quote icarus_icarus
I did check them when I went over the wiring. It also does shut down immediately when the door is closed when it does malfunction.
·Ď˘ĺrµ§·
Compustar CM6200 Wont Go Into Reservation Mode -- posted image.
lurch228 
Silver - Posts: 1,338
Silver spacespace
Joined: August 08, 2012
Posted: November 11, 2018 at 5:05 AM / IP Logged Link to Post Post Reply Quote lurch228
So when the door switch is tested with a DMM and you wiggle the switch there is no variation in the reading. The R/S will think the door was opened closed and opened even if its only for 10ms which would only look like a slight flicker to the eye.
icarus_icarus 
Copper - Posts: 229
Copper spacespace
Joined: November 01, 2005
Location: Ontario, Canada
Posted: November 11, 2018 at 5:07 AM / IP Logged Link to Post Post Reply Quote icarus_icarus
I didn't notice any, but will check them again. I had to press them in about 2mm before they even registered...
·Ď˘ĺrµ§·
Compustar CM6200 Wont Go Into Reservation Mode -- posted image.
lurch228 
Silver - Posts: 1,338
Silver spacespace
Joined: August 08, 2012
Posted: November 11, 2018 at 5:39 AM / IP Logged Link to Post Post Reply Quote lurch228
With you system there are four monitored inputs for the reservation mode.
!. Footbrake
2. Parking brake
3. Hood pin
4. Door pin(s)
Any one of the switches or the wiring to them needs to be verified to have solid connections and proper function.
Otherwise try unplugging the brain from both power and ground and then connect the units power and ground together to drain any residual power for 5 minutes.
If problem persists likely unit has gone bad.
iskidoo 
Silver - Posts: 1,040
Silver spaceThis member has made a donation to the12volt.com. Click here for more info.spacespace
Joined: December 08, 2002
Location: Maine, United States
Posted: November 11, 2018 at 7:01 PM / IP Logged Link to Post Post Reply Quote iskidoo
If the door switch is the same on driver and passenger side, try swapping them. Should tell you wether it’s the driver switch that’s an issue or not.
Steve G

If you wish to post a reply to this topic, you must first login.
If you are not already registered, you must first register.

  Printable version Printable version Post ReplyPost New Topic
You cannot post new topics in this forum
You cannot reply to topics in this forum
You cannot delete your posts in this forum
You cannot edit your posts in this forum
You cannot create polls in this forum
You cannot vote in polls in this forum

  •  
Search the12volt.com
Follow the12volt.com Follow the12volt.com on Facebook
Thursday, March 28, 2024 • Copyright © 1999-2024 the12volt.com, All Rights Reserved Privacy Policy & Use of Cookies
Disclaimer: *All information on this site ( the12volt.com ) is provided "as is" without any warranty of any kind, either expressed or implied, including but not limited to fitness for a particular use. Any user assumes the entire risk as to the accuracy and use of this information. Please verify all wire colors and diagrams before applying any information.

Secured by Sectigo
the12volt.com spacer
the12volt.com spacer
the12volt.com spacer
Support the12volt.com
Top
the12volt.com spacer
the12volt.com spacer