2005 malibu no start or instr cluster

Just wired up a 2005 malibu with ads-al-ca from idatlink and have had no problems at all installing these. Until today... When it was all wired up ,it failed to program.upon trying to start with key it would run but only for a few seconds.There is no power to the dash- no lights except the engine light.No fuel guage,no passlock lights nothing..Tested all fuses under hood and at bcm ,checked fuse box for corrosion etc all good.. There is power on the brown acc wire at ignition switch,and ignition power on yellow wire at ignition switch when key is cycled.. Any thoughts or help would be greatly appreciated Bruce

is this a malibu, malibu classic, or max

Regular 05 malibu 4 cyl

Malibu Classic wiring Item     Wire Color     Polarity     Wire Location 12 Volts     red     +     ignition harness      Remove the radio, without unplugging it, to access the ignition harness. Second 12 Volts                Starter     yellow     +     ignition harness      Remove the radio, without unplugging it, to access the ignition harness. Second Starter     N/A           Ignition     pink     +     ignition harness      Remove the radio, without unplugging it, to access the ignition harness. Second Ignition     dk. green     +     ignition harness      Remove the radio, without unplugging it, to access the ignition harness. Third Ignition     N/A           Accessory     orange     +     ignition harness      Remove the radio, without unplugging it, to access the ignition harness. Second Accessory     brown     +     ignition harness      Remove the radio, without unplugging it, to access the ignition harness. Third Accessory     N/A           Keysense                Data Bus     yellow (resistor code), black (ground)     Passlock 2     Passlock sensor on ignition key cylinder Can Bus High                Can Bus Low                Can Bus Sw     purple     data     data link connector under driver dash, pin 2 Power Lock     white     -     driver kick, door harness      Lock requires a negative trigger, and unlock requires a negative trigger thru a 1,500 ohm resistor. MUST use relays. Must close doors to lock with a single pulse. Power Unlock     same wire as power lock           Lock Motor     gray     5wi     driver kick, door harness Driver Unlock Motor     tan     5wi     driver kick, door harness Parking Lights (-)                Parking Lights (+)     brown     +     passenger kick or column Hazards                Turn Signal (Left)                Turn Signal (Right)                Headlight     dk. blue & pink     -     steering column      Requires high current ground. MUST use relays. AutoLights                Reverse Light                Left Front Door Trigger     lt. GREEN/ black & lt. blue     -           The lt. GREEN/ black is located in the driver kick and catches only the driver door. The lt. blue is located in the harness coming from the driver running board going under the driver seat and it catches all other doors. Use both door trigger wires and diode isolate each. Right Front Door Trigger                Left Rear Door Trigger                Right Rear Door Trigger                Dome Supervision     white     -     dash light or column Trunk/Hatch Pin     ORANGE / black     -     light in trunk Rear Glass Pin                Hood Pin                Trunk/Hatch Release     BLACK/ white     +     driver kick panel Trunk Release Motor                Fuel Door Release                Power Sliding Door (Left)     N/A           Power Sliding Door (Right)                Factory Alarm Arm                Factory Alarm Disarm                Disarm No Unlock                Trunk Alarm Shunt                Tachometer     PURPLE / white     ac     ignition coil or ECM      The ECM (Engine Control Module) is located under the driver side dash to the left of the steering column. Wait to Start     N/A           Neutral Safety                Clutch Pedal                Fuel Pump                Rear Defroster                Mirror Defroster                Left Front Heated Seat                Right Front Heated Seat                Speed Sense     dk. GREEN / WHITE          ECM      The ECM (Engine Control Module) is located under the driver side dash to the left of the steering column. Brake Wire     lt. blue     +     brake pedal switch Parking Brake                Horn Trigger     black     -     steering column Wipers     dk. green & purple     +     steering column Malibu Reg and Maxx Item     Wire Color     Polarity     Wire Location 12 Volts     RED / black (50A)     +     BCM, C3, pin D1      The BCM (Body Control Module) is part of the fuse/relay box on the front passenger side of the center console. It has the following connectors: C1-72 pin gray plug, C2-72 pin gray plug, C3-41 pin red plug, and C4-68 pin lt. gray plug. Second 12 Volts     RED / black (30A)     +     BCM, C3, pin D12      The BCM (Body Control Module) is part of the fuse/relay box on the front passenger side of the center console. It has the following connectors: C1-72 pin gray plug, C2-72 pin gray plug, C3-41 pin red plug, and C4-68 pin lt. gray plug. Starter     yellow (not for remote start)     -     PCM, blue plug, pin 48 or 23      The PCM (Powertrain Control Module) is in front of the battery on the driver side fender. Second Starter     white     +9.6K ohms     ignition harness or BCM, C2, pin 56      The BCM (Body Control Module) is part of the fuse/relay box on the front passenger side of the center console. It has the following connectors: C1-72 pin gray plug, C2-72 pin gray plug, C3-41 pin red plug, and C4-68 pin lt. gray plug. If interface module is not available, see Tech Doc 1605. Ignition     pink     +     ignition harness or BCM, C4, pin D3      The BCM (Body Control Module) is part of the fuse/relay box on the front passenger side of the center console. It has the following connectors: C1-72 pin gray plug, C2-72 pin gray plug, C3-41 pin red plug, and C4-68 pin lt. gray plug. Second Ignition     N/A           Third Ignition     N/A           Accessory     brown     +     ignition harness or BCM, C4, pin C8      The BCM (Body Control Module) is part of the fuse/relay box on the front passenger side of the center console. It has the following connectors: C1-72 pin gray plug, C2-72 pin gray plug, C3-41 pin red plug, and C4-68 pin lt. gray plug. Second Accessory     same as second starter     +6.3K ohms      Third Accessory     N/A           Keysense     same as second starter           Data Bus     white (resistor code), WHITE/ black (5V reference)     mux     ignition harness or BCM, C2, pins 56 and 62      The BCM (Body Control Module) is part of the fuse/relay box on the front passenger side of the center console. It has the following connectors: C1-72 pin gray plug, C2-72 pin gray plug, C3-41 pin red plug, and C4-68 pin lt. gray plug. The keyless link wire is lt. green at the BCM, C2, pin 12. Can Bus High                Can Bus Low                Can Bus Sw     dk. green     data     data link connector under driver dash, pin 1 Power Lock     white     -     driver kick or BCM, C1, pin 66      Lock is a straight negative trigger. Unlock is negative trigger thru a 1.5K ohm resistor. MUST use relays. The BCM (Body Control Module) is part of the fuse/relay box on the front passenger side of the center console. It has the following connectors: C1-72 pin gray plug, C2-72 pin gray plug, C3-41 pin red plug, and C4-68 pin lt. gray plug. Power Unlock     same as power lock wire           Lock Motor     gray/black to gray     5wi     driver kick or BCM, C3, pin A5      The BCM (Body Control Module) is part of the fuse/relay box on the front passenger side of the center console. It has the following connectors: C1-72 pin gray plug, C2-72 pin gray plug, C3-41 pin red plug, and C4-68 pin lt. gray plug. Driver Unlock Motor     tan     5wi     driver kick or BCM, C3, pin B1      The BCM (Body Control Module) is part of the fuse/relay box on the front passenger side of the center console. It has the following connectors: C1-72 pin gray plug, C2-72 pin gray plug, C3-41 pin red plug, and C4-68 pin lt. gray plug. Parking Lights (-)     BROWN / white     -     switch or BCM, C2, pin 5      The BCM (Body Control Module) is part of the fuse/relay box on the front passenger side of the center console. It has the following connectors: C1-72 pin gray plug, C2-72 pin gray plug, C3-41 pin red plug, and C4-68 pin lt. gray plug. Parking Lights (+)     brown     +     driver kick or BCM, C3, pin A7      The BCM (Body Control Module) is part of the fuse/relay box on the front passenger side of the center console. It has the following connectors: C1-72 pin gray plug, C2-72 pin gray plug, C3-41 pin red plug, and C4-68 pin lt. gray plug. Hazards     white     -     switch or BCM, C2, pin 9      The BCM (Body Control Module) is part of the fuse/relay box on the front passenger side of the center console. It has the following connectors: C1-72 pin gray plug, C2-72 pin gray plug, C3-41 pin red plug, and C4-68 pin lt. gray plug. Turn Signal (Left)     dk. blue (F), yellow (R)     +     BCM, C1, pin 38 and C3, pin A9      The BCM (Body Control Module) is part of the fuse/relay box on the front passenger side of the center console. It has the following connectors: C1-72 pin gray plug, C2-72 pin gray plug, C3-41 pin red plug, and C4-68 pin lt. gray plug. Turn Signal (Right)     dk. green (F), dk. green (R)     +     BCM, C1, pin 56 and C3, pin A12      The BCM (Body Control Module) is part of the fuse/relay box on the front passenger side of the center console. It has the following connectors: C1-72 pin gray plug, C2-72 pin gray plug, C3-41 pin red plug, and C4-68 pin lt. gray plug. Headlight     white     -     switch or BCM, C2, pin 15      The BCM (Body Control Module) is part of the fuse/relay box on the front passenger side of the center console. It has the following connectors: C1-72 pin gray plug, C2-72 pin gray plug, C3-41 pin red plug, and C4-68 pin lt. gray plug. AutoLights                Reverse Light     lt. green     +     fuse block, driver side of trunk Left Front Door Trigger     gray/black (D), tan/white (P)     -     each kick or BCM, C1, pins 51 and 72      Use both wires and diode isolate each. The BCM (Body Control Module) is part of the fuse/relay box on the front passenger side of the center console. It has the following connectors: C1-72 pin gray plug, C2-72 pin gray plug, C3-41 pin red plug, and C4-68 pin lt. gray plug. Right Front Door Trigger                Left Rear Door Trigger                Right Rear Door Trigger                Dome Supervision     gray     -     BCM, C3, pin A10      The BCM (Body Control Module) is part of the fuse/relay box on the front passenger side of the center console. It has the following connectors: C1-72 pin gray plug, C2-72 pin gray plug, C3-41 pin red plug, and C4-68 pin lt. gray plug. Trunk/Hatch Pin     ORANGE / black     -     BCM, C1, pin 18      The BCM (Body Control Module) is part of the fuse/relay box on the front passenger side of the center console. It has the following connectors: C1-72 pin gray plug, C2-72 pin gray plug, C3-41 pin red plug, and C4-68 pin lt. gray plug. Rear Glass Pin                Hood Pin     pink/black     -     pin switch or BCM, C1, pin 69      The BCM (Body Control Module) is part of the fuse/relay box on the front passenger side of the center console. It has the following connectors: C1-72 pin gray plug, C2-72 pin gray plug, C3-41 pin red plug, and C4-68 pin lt. gray plug. Trunk/Hatch Release     BROWN / white     -     switch or BCM, C1, pin 71      The BCM (Body Control Module) is part of the fuse/relay box on the front passenger side of the center console. It has the following connectors: C1-72 pin gray plug, C2-72 pin gray plug, C3-41 pin red plug, and C4-68 pin lt. gray plug. Trunk Release Motor                Fuel Door Release                Power Sliding Door (Left)     N/A           Power Sliding Door (Right)                Factory Alarm Arm     arms on lock with door open           Factory Alarm Disarm     purple     -     driver kick, door harness      This wire will disarm the factory alarm if it has not been triggered, but might not disarm if it has. This wire will also unlock the doors with a double pulse. Disarm No Unlock     with ignition and Passkey           Trunk Alarm Shunt                Tachometer     NOT pink     ac     any fuel injector Wait to Start     N/A           Neutral Safety                Clutch Pedal                Fuel Pump                Rear Defroster                Mirror Defroster                Left Front Heated Seat                Right Front Heated Seat                Speed Sense     brown (3.5L only)          PCM, blue plug, pin 22      The PCM (Powertrain Control Module) is in front of the battery on the driver side fender. Brake Wire     white     +     BCM, C1, pin 42      The BCM (Body Control Module) is part of the fuse/relay box on the front passenger side of the center console. It has the following connectors: C1-72 pin gray plug, C2-72 pin gray plug, C3-41 pin red plug, and C4-68 pin lt. gray plug. Parking Brake     lt. blue     -     switch or BCM, C1, pin 59      The BCM (Body Control Module) is part of the fuse/relay box on the front passenger side of the center console. It has the following connectors: C1-72 pin gray plug, C2-72 pin gray plug, C3-41 pin red plug, and C4-68 pin lt. gray plug. Horn Trigger     tan     -     switch or BCM, C2, pin 14      The BCM (Body Control Module) is part of the fuse/relay box on the front passenger side of the center console. It has the following connectors: C1-72 pin gray plug, C2-72 pin gray plug, C3-41 pin red plug, and C4-68 pin lt. gray plug. Wipers     dk. green     +     BCM, C1, pin 22      The BCM (Body Control Module) is part of the fuse/relay box on the front passenger side of the center console. It has the following connectors: C1-72 pin gray plug, C2-72 pin gray plug, C3-41 pin red plug, and C4-68 pin lt. gray plug.

Something strange happened.I have done this vehicle type many times with no problem.this could be related to the remote or not.Right now I have no wires hooked up,the car is back to original and still no power to dash cluster- no lights except engine ,no security.no guages.Car will start and run 2-3 sec and quit.What powers dash bcm or pcm? Bruce

may want to start checking all fuses

change out the harneses for thei datalink bypass. I have come across some bad harneses, only a few and this will cause problems like this. Also call I datalink tech support and they will walk you through the process to test the harnes wireing. If you used the 3pin blue harness with the white WHITE/ red,WHITE/ black. Replace this harness first. It probaly is the problem. I have had three of the harnesses not work for some reason.  Also If i remember corectly on this vehical one of the ignition wires is opened up and connects to this harness. Try a dirffent module to just incase its bad too.Solartech Window Tinting and Electronics,contract installer

I know you said you checked all fuses and tested ignition and accessory wires, but still, here's where I would go with it. Test all five wires at the ignition switch for proper operation. 1. RED / white. Should have constant power. Protected by 2-amp fuse at BCM on right side of center console. 2. WHITE/ black 5-volt Reference. Should be about 5 volts at all times. 3. White Off/Run/Crank. ADS incorrectly refers to this as the "Passlock" wire, even though these cars don't have Passlock, only Passkey. Anyway, the Off/Run/Crank should show 12 volts positive with the key in the ignition, and then test at various other voltages with the key in the Accessory, Run, and Start positions. Also, take note of whether the key-in-ignition chime works, by inserting the key in the ignition with the door open. 4. Brown Accessory. I'm sure you know how to test an accessory wire. 5. Yellow Ignition. Test this too, of course. -------------------------- Besides that, isn't there a wire at the PK3 module that you have to interrupt? Test both sides of that wire to make sure you made good connections, and to make sure the internal relay in the module is working correctly. Maybe even consider putting the wire back together like factory just for testing. Also, you said no power to the dash.....but how about other things like windows, radio, and climate controls? If all else fails, never hurts to try disconnecting the car's battery for a few minutes. Might want to write down the customer's radio presets so you can reprogram them when done.

I would hope after 8 months they got the car figured out!Kevin Pierson